裂缝性致密砂岩气藏水相毛管自吸调控

doi:10.11867/j.issn.1001-8166.2013.01.0079

地球科学进展 ›› 2013, Vol. 28 ›› Issue (1): 79 -85. doi: 10.11867/j.issn.1001-8166.2013.01.0079

裂缝性致密砂岩气藏水相毛管自吸调控

游利军，康毅力

油气藏地质及开发工程国家重点实验室，西南石油大学，四川成都610500

收稿日期:2012-06-25 修回日期:2012-11-15 出版日期:2013-01-10
通讯作者: 游利军（1976-），男，河南洛阳人，副教授，主要从事油气层保护理论与技术、岩石物理、非常规天然气教学和科研工作. E-mail:youlj0379@126.com
基金资助:
国家重点基础研究发展计划项目“深井复杂地层漏失与井壁失稳机理及预测”（编号：2010CB226705）；国家科技重大专项“页岩气层工程作业适应性及储层保护对策研究”（编号：2011ZX05018-005HZ）资助.

Aqueous Capillary Imbibition Behavior Management in Fractured Tight Gas Reservoirs

You Lijun, Kang Yili

State Key Laboratory of Oil and Gas Reservoir Geology and Exploitation, Southwest Petroleum University, Chengdu610500, China

Received:2012-06-25 Revised:2012-11-15 Online:2013-01-10 Published:2013-01-10

下载PDF ( 984 )

钻井、完井、增产改造工作液滤液、边底水或凝析水在井筒或裂缝面附近发生毛管自吸行为和滞留效应诱发水相圈闭损害，妨碍气藏的及时发现、准确评价和经济开发。以我国四川、鄂尔多斯盆地典型致密砂岩气藏为例，基于致密气藏天然气产出机理，分析了致密气藏经济开发的水平井钻井完井、水力压裂、采气等作业环节中水相自吸过程及其对作业效果的影响。钻井完井过程中水相快速自吸进入基块，驱替出非润湿相油气，打破裂缝壁面力学—化学平衡，诱发井壁失稳；进入裂缝的工作液要快速返排，以免自吸侵入基块降低基块—裂缝传质效率；裂缝中水相高速流动，不易毛管自吸进入基块，造成边底水沿裂缝快速推进，造成水淹。矿场工程技术实践证明，裂缝致密气藏勘探开发全过程，选用合理水基工作流体体系，改善采气工艺措施，调控毛管自吸，进而达到防治水相圈闭损害的目的，是经济开发致密气藏的关键。

关键词: 毛管自吸, 致密气藏, 水相圈闭损害, 井壁失稳, 水平井

The filtration of drilling, completion and stimulation fluids, edge water and bottom water can spontaneously imbibe into and be blocked in the matrix adjacent to wellbore and fractures, which induces water phase trapping damage, preventing gas reservoir from identification, accurate assessment and economic development. The imbibition phenomena of tight sandstone gas reservoirs in west Sichuan basin and north Ordos basin during horizontal well drilling and completion, hydraulic fracturing and gas production operations are investigated on the basis of the production mechanisms of tight gas. The analysis of effects of well operation exerted by water phase imibibiton indicates that the water rapidly imbibes into matrix and displaces oil and gas, which breaks the chemical and mechanical balance and induces the borehole instability, that working fluids invading into fractures should return as soon as possible in case they imbibe into matrix and damage the fracture face, and that water proceeding along the fracture fast in fracture can be difficult to imbibe into matrix and induce waterflooding during gas production. The practices in oilfields fully prove that capillary imbibition management by optimizing water-based fluids and improving technical measures of gas production are and will be playing increasing role in preventing water phase trapping damage and economically developing fractured tight gas reservoirs.

Key words: Capillary imbibition, Tight gas reservoirs, Water phase trapping, Borehole instability, Horizontal well

中图分类号:

TE258
TE371

[1]Zhang Zhiqiang, Zheng Junwei. Advances in exploration and exploitation technologies of low-permeability oil and gas[J]. Advances in Earth Science, 2009, 24(8): 854-864.[张志强,郑军卫. 低渗透油气资源勘探开发技术进展[J]. 地球科学进展，2009, 24(8): 854-864.]

[2]You Lijun, Kang Yili. Integrated evaluation of water phase trapping damage potential in tight gas reservoirs[C]∥SPE 122034, Presented at the 2009 SPE European Formation Damage Conference. Scheveningen, Netherlands, 2009:27-29.

[3]Dai Jinxing, Ni Yunyan, Wu Xiaoqi. Tight gas in China and its significance in exploration and exploitation[J].Petroleum Exploration and Development, 2012, 39(3):257-263.[戴金星,倪云燕,吴小奇. 中国致密砂岩气及在勘探开发上的重要意义[J]. 石油勘探与开发, 2012, 39(3):257-263.]

[4]Lin Chunming, Zhang Xia, Zhou Jian,et al. Diagenesis characteristics of the reservoir sandstones in lower Shihezi Formation from Daniudi Gas Field, Ordos Basin[J]. Advances in Earth Science,2011, 26(2): 212-223.[林春明, 张霞，周健，等. 鄂尔多斯盆地大牛地气田下石盒子组储层成岩作用特征[J]. 地球科学进展，2011, 26(2): 212-223.]

[5]Li Mingcheng,Li Jian.“Dynamic trap”:A main action of hydrocarbon charging to form accumulations in low permeability-tight reservoir[J].Acta Petrolei Sinica,2010,21(5):718-722.[李明诚，李剑. “动力圈闭”——低渗透致密储层中油气充注成藏的主要作用[J].石油学报,2010,21(5): 718-722.]

[6]Newsham K E, Rushing J A, Lasswell P M. Use of vapor desorption data to characterize high capillary pressure in a basin-centered gas accumulation with ultra-low connate water saturations[C]∥SPE 84596, Presented at SPE Annal Technical Conference and Exhibition. Denver,Colorado,U.S.A,2003:5-8.

[7]Bennion D B, Bietz R F, Thomas F B, et al. Reductions in the productivity of oil and low permeability gas reservoirs due to aqueous phase trapping[J].Journal of Crgstallization Process and Technology,1994, 33(8)：45-54.

[8]Li K, Chow K, Horne R N. Influence of initial water saturation on recovery by spontaneous imbibition in gas-water-rock systems and the calculation of relative permeability[J]. Speree,2006,9(4):295-301.

[9]Wang Jialu, Liu Yuzhang, Chen Maoqian,et al. Experimental study on dynamic imbibition mechanism of low permeability reservoirs[J].Petroleum Exploration and Development, 2009, 36(1): 86-90.[王家禄, 刘玉章, 陈茂谦, 等. 低渗透油藏裂缝动态渗吸机理实验研究[J]. 石油勘探与开发, 2009, 36(1): 86-90.]

[10]You Lijun, Kang Yili. Progress in research on spontaneous capillary imbibition of oil and gas reservoir rocks[J]. Journal of Southwest Petroleum University(Science & Technology Edition), 2009,31(4):112-116.[游利军，康毅力.油气储层岩石毛管自吸研究新进展[J].西南石油大学学报：自然科学版，2009,31(4):112-116.]

[11]Roberto Aguilera. Role of natural fractures and slot porosity on tight gas sands[C]∥SPE 114174, Presented at the 2008 SPE Unconventional Reservoirs Conference. Keystone, Colorado,U.S.A.,2008:10-12.

[12]Pongratz R, Gijtenbeek von K, Kontarev R, et al. Perforating for fracturing-best practices and case histories[C]∥SPE 105064, Presented at the 2007 SPE Hydraulic Fracturing Technology Conference. College Station,Texas,U.S.A.,2007:29-31.

[13]Li Shilun, Pan Yi, Sun Lei. An new idea on enhancing the recovery rate of condensate gas reservoirs[J]. Natural Gas Industry,2008,28(9)：1-5.[李士伦, 潘毅, 孙雷. 提高凝析气藏采收率的新思路[J]. 天然气工业, 2008,28(9)：1-5.]

[14]Ding Wenlong, Xu Changchun, Jiu Kai. The research progress of shale fractures[J]. Advances in Earth Science, 2011,26(2):135-144.[丁文龙, 许长春, 久凯. 泥页岩裂缝研究进展[J]. 地球科学进展,2011, 26(2):135-144.]

[15]Hutton F,Payne T, Jeffreys K,et al. Fusible-particle system helps to control severe lost circulation while drilling across a fractured zone in Elk Hills Field,CA[C]∥SPE 121111, Presented at the 2009 SPE Western Regional Meeting. San Jose,California,USA,2009:24-26.

[16]Sun Jinsheng. Film Forming Technology of Water Based Drilling Fluids[D]. Chengdu: Southwest Petroleum University,2006.[孙金生. 水基钻井液成膜技术研究[D].成都：西南石油大学, 2006.]

[17]Zhang Yan, Xiang Xingjin, Yan Jienian,et al. A novel drilling fluid with less free water[J]. Petroleum Exploration and Development,2011, 38(4):490-494.[张岩, 向兴金, 鄢捷年, 等. 低自由水钻井液体系[J]. 石油勘探与开发, 2011, 38(4):490-494.]

[18]Xu Jianhai, Li Mei,Zhao Yan,et al. Advance of wetting behavior research on the superhydrophobic surface with Micro.and Nano-Structures[J].Progress in Chemistry, 2006, 18(11):1 425-1 433.[徐建海, 李梅, 赵燕, 等. 具有纳微米结构超疏水表面润湿性的研究[J]. 化学进展, 2006, 18(11):1 425-1 433.]

[19]Liu Xuefen, Kang Yili, You Lijun.Application of sufactants to whole formation dam age control for low permeability reservoirs[J].Oil Field Chemistry,2010,27（2）:216-220.[刘雪芬，康毅力，游利军. 表面活性剂在低渗透油气藏全过程保护中的应用进展[J].油田化学，2010，27（2）：216-220.]

[20]Kang Y, You L, Xu X, et al. Prevention of formation damage induced by mud lost in deep fractured tight gas reservoir in Western Sichuan Basin[J]. Journal of Canadion Petrolem Technology, 2012, 51(1):46-51.

[21]Kang Yili, Luo Pingya, Xu Jin, et al. Employing both damage control and stimulation: A way to successful development for tight gas sandstone reservoirs[C]∥SPE 64707, Presented at International Oil and Gas Conference and Exhibition in China,November. Beijing, 2000:7-10.

[22]Zhu Weiyao. Spontaneous imbibition mechnism of flow through porous meadia and waterflooding in low-permeability fracture sandstone reserviors[J].Acta Petrolei Sinica, 2002,23(6):56-59.[朱维耀. 低渗透裂缝性砂岩油藏多孔介质渗吸机理研究[J]. 石油学报, 2002,23(6):56-59.]

[23]Rangel-Germn E R, Kovscek A R. Experimental and analytical study of multidimensional imbibition in fractured porous media[J]. Journal of Crystallization Process and Technology，2002, 36(1/2):45-60.

[24]Mahadevan J, Shamar M M．Factors affecting cleanup of waterblocks: A laboratory investigation[J]. Society of Petroleum Engiceers Jouroal，2005, 10(3):238-246.

[25]You Lijun, Kang Yili. Effects of thermal treatment on physical property of tight rocks[J].Progress in Geophysics,2009,24(5):1 850-1 854.[游利军，康毅力．热处理对致密岩石物理性质的影响[J].地球物理学进展，2009，24(5)：1 850-1 854.]

[26]Delavarmoghaddam A，Mirhaj S A，Zitha P L J．Gas condensate productivity improvement by chemical wettability alteration[C]∥SPE 122225，Presented at the 8th European Formation Damage Conference.Scheveningen， Netherlands，2009.

[27]Li Kewen, Firoozabadi A. Modeling gas-condensate relative permeabilities and the effect of wettability change to gas wetness[J]. Society of Petroleum Engiceers Jouroal, 2000,3(2): 139-149.

[28]Liu Y, Zheng H, Huang G, et al.Improving production in gas/condensate reservoirs by wettability alteration to gas wetness[C]∥SPE 99739, Presented at the 2006 SPE/DOE Symposium on Improved Oil Recovery. Tulsa, OK,2006.

[29]Liu Xuefen, Kang Yili, You Lijun,et al.Experimental study on amphiphobic surface treating to prevent reservoir from aqueous phase trapping damage[J]. Natural Gas Geoscience, 2009, 20（2）:292-296.[刘雪芬，康毅力，游利军，等.双疏性表面处理预防致密储层水相圈闭损害实验研究[J]．天然气地球科学，2009, 20（2）:292-296.]

No related articles found!

阅读次数

全文

摘要